SsangYong · 2011–2020
SsangYong car common jobs, manuals & parts · Turbo downsizing & ESP era
SsangYong 2011–2020 — turbo downsizing & esp era. 1.0–1.5 EcoBoost / TSI / PureTech triple- and four-cylinder turbo petrols, AdBlue diesels, mild-hybrid 48 V belt-starter-generators and the first mainstream BEVs. For UK SsangYong owners that means: Multiplexed CAN / LIN networks, start-stop AGM batteries, ZF 8HP automatics needing factory fluid, DPF / GPF service regens via OBD.
Multiplexed CAN / LIN networks, start-stop AGM batteries, ZF 8HP automatics needing factory fluid, DPF / GPF service regens via OBD.
Euro 6 (2014) and the Real Driving Emissions test (2017) reshape engineering; UK ULEZ launches London 2019, Birmingham 2021.
- Genuine OE SsangYong 2011–2020 body panels, doors, tailgates and bumpers from MOT-failed donors.
- Tested engines, gearboxes and ECUs — every supplier on sparecarpart is a verified UK breaker yard, not a drop-shipper.
- Service items mentioned in this era of manual (timing kits, water pumps, DMFs, DPFs) sourced as either OE-removed or OE-equivalent.
Common SsangYong jobs · 2011–2020
The 12 jobs UK garages and DIYers ask about most for SsangYong turbo downsizing & esp era. Each card shows the labour band, a parts request pre-filled for SsangYong, and a charm.li deep link where the free public manual covers it.
- 1–3hCharging & starting
Alternator replacement
Charge-light on, low cranking voltage or noisy bearing — swap the alternator and re-tension the auxiliary belt.
- 1–3hCharging & starting
Starter motor replacement
Hot-start failure, solenoid click or grinding pinion — drop the starter from above or below the bellhousing.
- 3–6hCooling
Water pump & coolant service
Weeping pump, low coolant or impeller noise — replace pump, refresh OAT/G12 coolant and bleed the system.
- 6h+Engine
Timing belt or chain replacement
Mileage-due belt, stretched chain or tensioner rattle — full kit with idler, tensioner and water pump where co-located.
- 6h+Transmission
Clutch kit & DMF
Slipping clutch, judder on pull-away or dual-mass rattle at idle — gearbox-out clutch kit and release-bearing swap.
- 1–3hBrakes
Brake discs & pads
Lipped discs, juddering under braking or low-pad warning — axle pair of discs plus matching friction kit.
- 3–6hExhaust
DPF regen, clean or replace
Permanent DPF light, forced-regen failure or backpressure fault — forced regen, off-car clean or new filter.
- AdBlue / SCR — handle DEF carefully
- 1–3hEmissions
EGR valve clean or replace
EGR fault code, rough idle or limp-home mode — clean carbon or fit a new valve and clear adaptations.
- 6h+Engine
Turbocharger replacement
Boost-leak code, smoke under load or shaft-play — full turbo replacement, oil-feed refresh and intercooler flush.
- 1–3hCooling
Radiator replacement
Pinhole leak, snapped plastic end-tank or coolant in the wrong place — drain, swap and bleed.
- 1–3hEngine electrical
Glow plug replacement
Cold-start misfire, glow-plug warning light or P0670 — full set of plugs and a relay check.
- 3–6hSuspension
Suspension arm & bushes
Knock over speed bumps, MOT advisory on ball-joints or perished bushes — replace arm and 4-wheel align.
No free workshop manual is hosted for SsangYong turbo downsizing & esp era — sparecarpart links each job straight to a UK parts quote and an independent SsangYong specialist instead.
SsangYong 2011–2020 · pick a model year
Every year here opens a UK parts quote pre-filled for your SsangYong model year. No free manual is hosted for this era.
Other SsangYong eras
- Where do I find a workshop manual for SsangYong 2011–2020?
- No free public workshop manual is hosted for SsangYong 2011–2020. Use the common-jobs grid above to send a free parts quote to UK breakers, and the specialist link to find an independent SsangYong garage that holds the factory data.
- What SsangYong parts do UK breakers actually stock for the turbo downsizing & esp era?
- Genuine OE SsangYong 2011–2020 body panels, doors, tailgates and bumpers from MOT-failed donors. Tested engines, gearboxes and ECUs — every supplier on sparecarpart is a verified UK breaker yard, not a drop-shipper. Service items mentioned in this era of manual (timing kits, water pumps, DMFs, DPFs) sourced as either OE-removed or OE-equivalent. Hybrid / EV high-voltage parts are handled only by ATF-certified breakers and shipped with appropriate paperwork.
- Are these SsangYong vehicles ULEZ / CAZ compliant?
- Euro 6 (2014) and the Real Driving Emissions test (2017) reshape engineering; UK ULEZ launches London 2019, Birmingham 2021.