Tesla · 2011–2020
Tesla car vehicle-era reference & parts paths · Turbo downsizing & ESP era
Tesla 2011–2020 — turbo downsizing & esp era. 1.0–1.5 EcoBoost / TSI / PureTech triple- and four-cylinder turbo petrols, AdBlue diesels, mild-hybrid 48 V belt-starter-generators and the first mainstream BEVs. For UK Tesla owners that means: Multiplexed CAN / LIN networks, start-stop AGM batteries, ZF 8HP automatics needing factory fluid, DPF / GPF service regens via OBD.
Multiplexed CAN / LIN networks, start-stop AGM batteries, ZF 8HP automatics needing factory fluid, DPF / GPF service regens via OBD.
Euro 6 (2014) and the Real Driving Emissions test (2017) reshape engineering; UK ULEZ launches London 2019, Birmingham 2021.
- Request OE Tesla 2011–2020 body panels, doors, tailgates and bumpers; the responding supplier must state source and condition.
- For engines, gearboxes and ECUs, ask for the donor details, test evidence, included components and written supplier terms.
- For service items mentioned in this era of manual, confirm whether the quoted item is OE-removed, remanufactured, new OE or aftermarket.
Tesla parts-request paths · 2011–2020
These are general component categories for the turbo downsizing & esp era, not a claim that every vehicle uses each system. Confirm engine, drivetrain and model-year applicability before ordering or starting work.
- 1–3hCharging & starting
Alternator replacement
Charge-light on, low cranking voltage or noisy bearing — swap the alternator and re-tension the auxiliary belt.
- 1–3hCharging & starting
Starter motor replacement
Hot-start failure, solenoid click or grinding pinion — drop the starter from above or below the bellhousing.
- 3–6hCooling
Water pump & coolant service
Weeping pump, low coolant or impeller noise — replace pump, refresh OAT/G12 coolant and bleed the system.
- 6h+Engine
Timing belt or chain replacement
Mileage-due belt, stretched chain or tensioner rattle — full kit with idler, tensioner and water pump where co-located.
- 6h+Transmission
Clutch kit & DMF
Slipping clutch, judder on pull-away or dual-mass rattle at idle — gearbox-out clutch kit and release-bearing swap.
- 1–3hBrakes
Brake discs & pads
Lipped discs, juddering under braking or low-pad warning — axle pair of discs plus matching friction kit.
- 3–6hExhaust
DPF regen, clean or replace
Permanent DPF light, forced-regen failure or backpressure fault — forced regen, off-car clean or new filter.
- AdBlue / SCR — handle DEF carefully
- 1–3hEmissions
EGR valve clean or replace
EGR fault code, rough idle or limp-home mode — clean carbon or fit a new valve and clear adaptations.
Tesla 2011–2020 · pick a model year
Every year opens the parts finder pre-filled for your Tesla model year. Confirm technical procedures with a suitably qualified repair professional.
Other Tesla eras
- Where can I confirm a repair procedure for Tesla 2011–2020?
- Use the job cards to prepare a parts request, then ask a suitably qualified independent Tesla specialist which licensed technical information applies to the exact model and year.
- What Tesla parts do UK breakers actually stock for the turbo downsizing & esp era?
- Request OE Tesla 2011–2020 body panels, doors, tailgates and bumpers; the responding supplier must state source and condition. For engines, gearboxes and ECUs, ask for the donor details, test evidence, included components and written supplier terms. For service items mentioned in this era of manual, confirm whether the quoted item is OE-removed, remanufactured, new OE or aftermarket. For hybrid or EV high-voltage parts, ask for provenance, test documentation, safe-transport details and the handler's relevant qualifications.
- Are these Tesla vehicles ULEZ / CAZ compliant?
- Euro 6 (2014) and the Real Driving Emissions test (2017) reshape engineering; UK ULEZ launches London 2019, Birmingham 2021.